 |
Coconut Shell Activated Carbon
Home > Products > Coconut Shell Activated Carbon
Carbon has unique properties that make it a multipurpose element. Coconut Shell Activated Carbon is widely used as a water purifier. Activated carbons that are manufactured from the shell of the coconut are of better quality and effective as compared to those manufactured from other sources. It is available in powdered as well as granular form to suit the different utilities of the clients. The activated carbon that we provide is largely used in various gas and liquid applications like waste water treatment, water filter, etc. It can be readily availed in different sizes of 2x4, 4x8, 8x16 and 5x10. We are reckoned as one of the prime Coconut Shell Based Activated Carbon Manufacturers in India.
Our Offer as Follows :
Annexure I : Design Basis & Treatment Scheme.
Annexure II : Scope of Supply.
Annexure III : List of Equipments.
Annexure IV : Schedule of Exclusions.
Annexure V : Commercial terms and conditions.
ANNEXURE I
REQUIREMENT : You have indicated your requirement of R.O plant cap. 250 LPH
Design Basis : We have designed the R.O Plant of cap.250 LPH Based upon approx. water T.D.S 800 mg /ltr.
PROPOSAL :Based on the above , we have designed the following water treatment scheme, as per your requirement.
MULTIGRADE SAND FILTER : The raw water shall be passed through coarse filtration sand filter, so as to get outlet water quality of< 5 NTU. TURBIDITY.
ACTIVATED CARBON FILTER : The filtered water pass through activated carbon for prevention of organic fouling
In membrane.
ANTISCALENT DOSING : The antiscalent on line dosing with filtered water to prevent scaling in R.O membranes.
MICRON FILTERATION : The water from the above unit shall be passed through a cartridges filter assembly with cartridge of 5 micron nominal rating. this has been incorporated to carry on fine Filtration before feeding the water to R.O membranes this will avoid chocking of the R. O. Membranes.
R.O. WATER PRESSURISATION : The R.O Plant works on the higher pressure because it has to overcome osmotic pressure therefore the feed water to the R.O is first pressurized by pumping it to through a high pressure pumps.
DESALINATION BY REVERSE OSOMOSIS : Pressurized water from the high pressure pump is feed to the reverse osmosis unit. The feed system gets divided into a permeate stream flow , in dissolved salts and brine or reject stream of very high in dissolve salts. Dissolved salts rejected by membrane are continuously flushed from the system via brine stream . the pure water permeates through the wall into the fiber bore and is collected at the end of the devices.
The R.O Permeate water shall be than confirming to the following treated water analysis.
T.D.S : >50 mg/ltr
pH : 5.5-6.5
Quantity : 250 LPH
Recovery : 15 %
ANNEXURE II
SCOPE OF SUPPL
RAW WATER FEED PUMP
Qty : 01
Make : Kirloskar /Eq.
Model : KDS 128+
Power : 01 H.P
MOC : C.I
MULTI GRADE FILTER
Qty : 01
Dia : 250 mm
Bed depth : 1000 mm
Flow rate : 1.5 m3/Hr
Max. Working press. : 3.5 kg/cm2
Mini. working press. : 2.0 kg/cm2
MOC : FRP
Max inlet turbidity : 25 NTU
Make vessel : Pentair
ACTIVATED CARBON FILTER
Qty : 01
Dia : 250 mm
Bed depth : 1000 mm
Flow rate : 1.5 m3/Hr
Max. Working press. : 3.5 kg/cm2
Mini . working press. : 2.0 kg/cm2
MOC : FRP
Max inlet turbidity : <5 NTU
Make vessel : Pentair
ANTISCALENT DOSING
Qty : 01
Make : Injecta/ Eq..
Type : Metering
Model : EBA-2
Capacity : 0-6 ltrs/Hr
Chemical tank cap. : 100 ltrs( HDPE)
CARTRIDGE FILTER
Housing : 01
No. : 1
Cartridge make : Filterite(USA)
Cartridge Size : 20”
Micron rating : 5
Housing MOC : P.P
HIGH PRESSURE PUMP
Qty : 01
Make : Sumo/Eq.
Model : CDL 1-230
Working pressure. : 10 kg/cm2
Power : 1.1 KW
MOC : SS 304
R.O SYSTEM
Membranes : Polyamide
Nos : 01
Make : Filmtech (Dow)/ Equivalent.
Size of membranes : 4” x 40”(TW 4040)
Qty of Housing : 01
MOC of pressure tubes : FRP (Maxima)
R.O Skid : 01
SS piping/ Fittings : one lot
MEMBRANE CLEANING AND FLUSHING SYSTEM
Pump : 01
MOC : SS-304
Make : Fisher/Eq.
Power : 0.5 H.P
Head : 30M
Tank : 01
MOC : HDPE
Volume : 100 Ltrs.
Micron filter : 01 No.
MOC : P.P
Size : 10”
Rating : 5 Micron
Make : Filterite(USA)
INTERCONNECTING PIPELINE
Qty : 01 lot
MOC : SS-304/PVC
Size : 20 mm
ANNEXURE III
LIST OF EQUIPMENTS
Raw water feed pump : 01
MGF : 01
ACF : 01
Antiscalent Dosing : 01
Micron filter : 01
High pressure pump : 01
R.O system complete with electric Control panel etc
Inter connecting pipeline : 01 lot
Membrane flushing and cleaning : 01 Set
System (Auto flushing) Instruments
Rota meter : 02
Pressure switches : 02
Pressure gauge : 04
Conductivity meter : 01
ANNEXURE IV
The following work will be excluded from our scope of supply.
ANNEXURE V
PRICE : 100000/-
VAT : As Applicable.
Freight : At Actual
Payment : 40% advance along with purchase order and balance against perform invoice/Inspection at our site.
Delivery : 3-4 weeks.
E & C : Excluding.
Warranty : 12 months against manufacturing defects only.
 |
Language :
Home | Company Profile | Products | Exchange Resin Processing | Contact Us | Inquiry | Sitemap |
 |
© Copyright 2010 - 2010. All Rights Reserved. ION ROBINSON INDIA.
Products Manufacturers - Manage by Indianyellowpages.com